MATERIAL SAFETY DATA SHEET
| Sheet No. 29 | Revision Date: 31 January 2012 |
|
|
|
MATERIAL SAFETY DATA SHEET |
||
| HMIS: Health- 1 Flammability- 1 Reactivity- 0 Pers. Protection- N |
NFPA: Health- 1 Flammability- 1 Reactivity- 0 Special Hazard- N |
WHMIS:
Not Applicable | ||
Section 1: Product and Company Identification |
Product: DEEP BLUE PTT Additive with Bio-enzymatic Digester
|
Synonyms: None |
| NILODOR, INC. | |
10966 INDUSTRIAL PARKWAY NW
BOLIVAR, OHIO 44612, USA |
|
Non-Emergency: |
24 hr Emergency Spill Information: |
US 800-443-4321
|
Chem-Tel, Inc. |
International 010-330-874-1017
|
US, Canada: 800-255-3924. International: 1-813-248-0584 |
Section 2. Hazards Identification
|
| EMERGENCY OVERVIEW | |
| Appearance/Odor: | Dark blue liquid, cherry fragrance |
| Classified as hazardous by the criteria of NOHSC. | |
| WARNING | |
| Flammability : | Not classified as flammable |
| Health Hazards Listed : Xi, R43 | |
| Ecological Hazards Listed : None known | |
| Potential Health Effects: See section 11 for more information. | |
| Likely Routes of Exposure: Skin, eyes | |
| Eye: | Irritant |
| Skin: | Can sensitize |
| Ingestion: | May cause mild digestive distress |
| Inhalation: | Not a problem |
| Medical Conditions Aggravated By Exposure: | |
| Allergies to fragrances | |
| Target Organs: | None known |
| This product does not contain any carcinogens or potential carcinogens as listed by OSHA, IARC or NTP. | |
| This material is not considered hazardous by the OSHA Hazard Communication Standard (29 CFR 1910.1200). | |
| Potential Environmental Effects: (See section 12 for more information.) | |
| None known | |
Section 3. Composition/Information on Ingredients
|
| Component | CAS# | % by Weight | WHMIS Controlled |
| Water | 7732-18-5 | 60 - 100 | N |
| Sodium Nitrate | 7631-99-4 | 7 - 13 | Y |
| Ethoxylated Linear Alcohol | 78330-21-9 | 0.5 - 1.5 | N |
| Alkoxylated Linear Alcohol | 68987-81-5 | 0.5 - 1.5 | N |
| Bacteria Culture | none | 0.1 - 1.0 | N |
Section 4. First Aid Measures |
| Eye Contact: | Flush eyes with copious amounts of clean water, holding lids open. Consult physician if irritation persists. |
| Skin Contact: | Wash with soap and water. |
| Inhalation: | Remove to fresh air. |
| Ingestion: | Give water or milk to drink. |
| Note to Physicians: | Contains a small quantity of Sodium Nitrate |
Section 5. Fire Fighting Measures |
| Suitable Extinguishing Media: | For surrounding fire |
| Unsuitable Extinguishing Media: | None known |
| Products of Combustion: | Oxides of carbon and nitrogen |
| Protection of Firefighters: | As for surrounding fire. |
Section 6. Accidental Release Measures
|
| Personal Precautions: | Avoid getting on skin or in eyes. |
| Environmental Precautions: | Keep out of surface waters. |
| Methods for Containment: | Dike with sand, clay or other suitable absorbent. |
| Methods for Clean-Up: | Absorb on sand, clay or other suitable absorbent. |
| Other Information: | Dispose in accordance with Commonwealth, State, and Local regulations. |
Section 7. Handling and Storage
|
| HANDLING |
| Keep off skin and out of eyes. |
| STORAGE |
| Keep in original container at ambient temperatures (less than 50°C/122°F) |
Section 8. Exposure Controls/Personal Protection |
| EXPOSURE GUIDELINES | ||
| COMPONENT: | TWA: | LD-50 |
| Water | Not applicable | Not applicable |
| Sodium Nitrate | None established | 1267 mg/kg |
| Ethoxylated Linear Alcohol | None established | Not determined |
| Alkoxylated Linear Alcohol | None established | Not determined |
| Bacteria Culture | Not applicable | Not applicable |
| Engineering Controls: No special requirements | ||
| Eye/Face Protection: Safety goggles if handling large quantities | ||
| Skin Protection: Rubber or other protective gloves if handling large quantities | ||
| Respiratory Protection: Not normally necessary | ||
| General Hygiene Considerations: Keep out of food and beverages | ||
Section 9. Physical and Chemical Properties
|
| Color: Intense dark blue | Odor: Cherry-like |
| Physical State: Liquid | Odor Treshhold: |
| pH: 7.0 - 9.0 | Freezing Point: Not determined |
| Evaporation Rate: As water | Boiling Point: 96°C/205°F |
| Flash Point: 71°C/160°F TCC | Flammability(solid,gas): Not applicable |
| Upper Flammability Limit: Not applicable | Lower Flammabilty Limit: Not applicable |
| Vapor Pressure: As water | Specific Gravity: 1.09 |
| Vapor Density: Not determined | Auto-ignition Temperature: Not determined |
| Volatile Organic Compound (VOC),%weight: | Solubility (water): Soluble |
| Less than 2 %, all fragrance | Percent Volatile: Less than 90% including water |
Section 10. Stability and Reactivity
|
| Stability: Stable |
| Conditions to Avoid: Not applicable |
| Incompatable Materials: None known |
| Hazardous Decomposition Products: Does not decompose under normal conditions |
| Possibility of Hazardous Reactions: Very unlikely |
Section 11. Toxicology Information
|
| ACCUTE EFFECTS | |
| Oral LD50: | Not established for mixture. Weighted average more than 2500 mg/kg |
| Dermal LD50: | Not classified as toxic by skin contact. Weighted average more than 5000 mg/kg |
| Inhalation: | Not classified as toxic by inhalation. Weighted average more than 10 mg/L. |
| Eye Irritation: | Direct contact may irritate eyes. |
| Skin Irritation: | Prolonged or repeated exposure may irritate skin. |
| Sensitization: | Prolonged or repeated exposure may sensitize skin. |
| CHRONIC EFFECTS | |
| Carcinogenicity: | None known |
| Mutagenicity: | None known |
| Reproductive Effects: | None known |
| Developmental Effects: | None known |
Section 12. Ecological Information
|
| Ecotoxicity: | Not applicable |
| Persistence/Degradability: | Biodegradable |
| Bioaccumulation/Accumulation: | Not applicable |
| Mobility in Enviroment: | Not applicable |
Section 13. Disposal Considerations
|
| Disposal: | Dispose of in accordance with Federal, State and Local regulations |
Section 14. Transportation Information |
| US DOT (ground) |
| Proper Shipping Description: Not a Hazardous Material |
| CANADA TDG (ground) |
| Proper Shipping Description: Not authorized for sale in Canada |
| ICAO (air) |
| Proper Shipping Description: Not a Dangerous Good |
| IMDG (water) |
| Proper Shipping Description: Not a Dangerous Good |
Section 15. Regulatory Information
|
| Global Inventories | |
| TSCA: United States | Included |
| DSL: Canada | Included |
| ECL: Korea | Not-Known |
| PICCS: Philippines | Not-Known |
| ENCS: Japan | Not-Known |
| AICS: Australia | Included |
| IECS: China | Not-Known |
| EINECS: European Union | Included |
| SARA 313 Information : | No Sara 313 Ingredients |
| California Safe Drinking Water and Toxic Enforcement Act pf 1986 :(Proposition 65) | |
| No Proposition 65 Ingredients | |
| WHMIS: Canadian Workplace Hazardous Material Information System | |
| Not Applicable | |
Section 16. Other Information
|
| Legends: | |
| NFPA, HMIS: | |
| 0=Minimal Hazard, 1=Slight Hazard, 2=Moderate Hazard, 3=Severe Hazard, 4=Extreme Hazard | |
| Prepared By: | Technical Dept. |
| While we believe that the data contained herein are factual and the opinions expressed are those of qualified experts regarding the results of tests conducted, the data are not to be taken as warranty or representation for which we assume legal responsibility. The information is offered solely for your consideration, investigation and verification. Any use of these data and information must be determined by the user to be in accordance with federal, state and local laws. | |