MATERIAL SAFETY DATA SHEET
| Sheet No. 373 | Revision Date: 21 January 2009 |
|
|
|
MATERIAL SAFETY DATA SHEET |
||
| HMIS: Health- 1 Flammability- 0 Reactivity- 0 Pers. Protection- B |
NFPA: Health- 1 Flammability- 0 Reactivity- 0 Special Hazard- N |
WHMIS:
D 2 B | ||
Section 1: Product and Company Identification |
Product: Plant Detergent
|
Synonyms: |
| NILODOR, INC. | |
10966 INDUSTRIAL PARKWAY NW
BOLIVAR, OHIO 44612, USA |
|
Non-Emergency: |
24 hr Emergency Spill Information: |
US 800-443-4321
|
Chem-Tel, Inc. |
International 010-330-874-1017
|
US, Canada: 800-255-3924. International: 1-813-248-0584 |
Section 2. Hazards Identification
|
| EMERGENCY OVERVIEW | |
| Appearance/Odor: | White/pale yellow powder, citrus aroma |
| NOT Classified as hazardous by the criteria of NOHSC. | |
| WARNING | |
| Flammability : | Not classified as flammable |
| Health Hazards Listed : R 36: Irritating to eyes. | |
| Ecological Hazards Listed : None known | |
| Potential Health Effects: See section 11 for more information. | |
| Likely Routes of Exposure: Eyes, mouth | |
| Eye: | Direct exposure can irritate |
| Skin: | Prolonged or repeated exposure can irritate |
| Ingestion: | Can cause digestive distress |
| Inhalation: | Dust can irritate |
| Medical Conditions Aggravated By Exposure: | |
| Allergies to fragrances | |
| Target Organs: | None known |
| This product does not contain any carcinogens or potential carcinogens as listed by OSHA, IARC or NTP. | |
| This material is not considered hazardous by the OSHA Hazard Communication Standard (29 CFR 1910.1200). | |
| Potential Environmental Effects: (See section 12 for more information.) | |
| None known | |
Section 3. Composition/Information on Ingredients
|
| Component | CAS# | % by Weight | WHMIS Controlled |
| Sodium Carbonate | 497-19-8 | 40 - 60 | Y |
| Non-ionic surfactant | 9036-19-5 | 5-10 | Y |
| Sodium Borate | 1303-96-4 | 7 - 13 | Y |
| Sodium Metasilicate | 6834-92-0 | 5-10 | Y |
| Water | 7732-18-5 | 5-10 | N |
Section 4. First Aid Measures |
| Eye Contact: | Flush eye with copious amounts of clean water,holding lids open. If irritation persists get medical attention. |
| Skin Contact: | Wash with soap and water. |
| Inhalation: | Remove to fresh air. |
| Ingestion: | If conscious, give water or milk to drink. DO NOT INDUCE VOMITING. |
| Note to Physicians: | Product dissolves in water to form alkaline solution. Prolonged contact can severely irritate eyes and respiratory tract and can dry or irritate skin. |
Section 5. Fire Fighting Measures |
| Suitable Extinguishing Media: | Water, foam, carbon dioxide, dry chemical. |
| Unsuitable Extinguishing Media: | None known. |
| Products of Combustion: | Oxides of carbon, boron, nitrogen. |
| Protection of Firefighters: | Self-contained breathing apparatus if large quantities are involved. |
Section 6. Accidental Release Measures
|
| Personal Precautions: | Keep away from eyes and mouth. Avoid breathing dust. |
| Environmental Precautions: | Keep out of surface waters and sanitary sewers. |
| Methods for Containment: | Powder, not applicable. Solutions: dike area with sand, clay or other suitable material. |
| Methods for Clean-Up: | Sweep, shovel or scoop up powder for disposal. Absorb solutions on sand, clay or other suitable material or mop up with water. |
| Other Information: |
Section 7. Handling and Storage
|
| HANDLING |
| Do not open until ready to use. |
| STORAGE |
| Keep out of the reach of children. Store in original container at ambient conditions. |
Section 8. Exposure Controls/Personal Protection |
| EXPOSURE GUIDELINES | ||
| COMPONENT: | TWA: | LD-50 |
| Sodium Carbonate | Dust 10 mg/cubic meter | 4090 mg/kg |
| Non-ionic surfactant | None established | 707 mg/kg |
| Sodium Borate | 5 mg/cubic meter | >4500 mg/kg |
| Sodium Metasilicate | Dust 10 mg/cubic meter | > 1500 mg/kg |
| Water | None established | Not applicable |
| Engineering Controls: Not normally necessary. | ||
| Eye/Face Protection: Protective goggles if handling large quantities. | ||
| Skin Protection: Rubber or other protective gloves if handling large quantities. | ||
| Respiratory Protection: Dust mask or particulates respirator recommended. | ||
| General Hygiene Considerations: Reasonable care. Keep away from food and beverages. | ||
Section 9. Physical and Chemical Properties
|
| Color: White to pale yellow | Odor: Mild citrus |
| Physical State: Powder | Odor Treshhold: |
| pH: 8.5 - 10.5, 0.1% solution | Freezing Point: Not applicable |
| Evaporation Rate: Not applicable | Boiling Point: Not applicable |
| Flash Point: Not applicable | Flammability(solid,gas): Non-flammable |
| Upper Flammability Limit: Not applicable | Lower Flammabilty Limit: Not applicable |
| Vapor Pressure: Not determined | Specific Gravity: Bulk density more than 0.65 g/mL, tapped |
| Vapor Density: Not determined | Auto-ignition Temperature: Not applicable |
| Volatile Organic Compound (VOC),%weight: | Solubility (water): Minimum 0.35 % |
| 0.1% | Percent Volatile: Less than 20% including water of crystallization |
Section 10. Stability and Reactivity
|
| Stability: Stable |
| Conditions to Avoid: High temperatures |
| Incompatable Materials: Strong acids |
| Hazardous Decomposition Products: None known |
| Possibility of Hazardous Reactions: Very improbable |
Section 11. Toxicology Information
|
| ACCUTE EFFECTS | |
| Oral LD50: | Not determined for mixture. Weighted average more than 2900 mg/kg |
| Dermal LD50: | Weighted average more than 1000 mg/kg. |
| Inhalation: | Low volatility. Weighted average as dusts more than 2.5 milligrams per Liter. |
| Eye Irritation: | Direct contact can be severely irritating |
| Skin Irritation: | Prolonged or repeated contact can dry or irritate skin. |
| Sensitization: | None known |
| CHRONIC EFFECTS | |
| Carcinogenicity: | None known |
| Mutagenicity: | None known |
| Reproductive Effects: | None known |
| Developmental Effects: | None known |
Section 12. Ecological Information
|
| Ecotoxicity: | Not determined. |
| Persistence/Degradability: | Biodegradable. |
| Bioaccumulation/Accumulation: | Not determined. |
| Mobility in Enviroment: | Not determined. |
Section 13. Disposal Considerations
|
| Disposal: | Dispose according to Federal, State or Provincial, and Local regulations. |
Section 14. Transportation Information |
| US DOT (ground) |
| Proper Shipping Description: Not a Hazardous Material |
| CANADA TDG (ground) |
| Proper Shipping Description: Not a Dangerous Good |
| ICAO (air) |
| Proper Shipping Description: Not a Dangerous Good |
| IMDG (water) |
| Proper Shipping Description: Not a Dangerous Good |
Section 15. Regulatory Information
|
| Global Inventories | |
| TSCA: United States | Included |
| DSL: Canada | Included |
| ECL: Korea | Not-Known |
| PICCS: Philippines | Not-Known |
| ENCS: Japan | Not-Known |
| AICS: Australia | Included |
| IECS: China | Not-Known |
| EINECS: European Union | Included |
| SARA 313 Information : | Does not contain any SARA 313 substances |
| California Safe Drinking Water and Toxic Enforcement Act pf 1986 :(Proposition 65) | |
| Does not contain any Proposition 65 substances | |
| WHMIS: Canadian Workplace Hazardous Material Information System | |
| D 2 B | |
Section 16. Other Information
|
| Legends: | |
| NFPA, HMIS: | |
| 0=Minimal Hazard, 1=Slight Hazard, 2=Moderate Hazard, 3=Severe Hazard, 4=Extreme Hazard | |
| Prepared By: | Technical Dept. |
| While we believe that the data contained herein are factual and the opinions expressed are those of qualified experts regarding the results of tests conducted, the data are not to be taken as warranty or representation for which we assume legal responsibility. The information is offered solely for your consideration, investigation and verification. Any use of these data and information must be determined by the user to be in accordance with federal, state and local laws. | |