MATERIAL SAFETY DATA SHEET
| Sheet No. 406 | Revision Date: 21 June 2010 |
|
|
|
MATERIAL SAFETY DATA SHEET |
||
| HMIS: Health- 1 Flammability- 0 Reactivity- 0 Pers. Protection- N |
NFPA: Health- 1 Flammability- 0 Reactivity- 0 Special Hazard- N |
WHMIS:
non-hazardous | ||
Section 1: Product and Company Identification |
Product: Encapsulating Extraction Cleaner
|
Synonyms: |
| NILODOR, INC. | |
10966 INDUSTRIAL PARKWAY NW
BOLIVAR, OHIO 44612, USA |
|
Non-Emergency: |
24 hr Emergency Spill Information: |
US 800-443-4321
|
Chem-Tel, Inc. |
International 010-330-874-1017
|
US, Canada: 800-255-3924. International: 1-813-248-0584 |
Section 2. Hazards Identification
|
| EMERGENCY OVERVIEW | |
| Appearance/Odor: | Pale yellow liquid, characteristic aroma |
| NOT Classified as hazardous by the criteria of NOHSC. | |
| WARNING | |
| Flammability : | NA |
| Health Hazards Listed : May be a mild irritant | |
| Ecological Hazards Listed : None known | |
| Potential Health Effects: See section 11 for more information. | |
| Likely Routes of Exposure: Skin, eyes | |
| Eye: | Direct exposure can irritate |
| Skin: | Prolonged exposure can irritate |
| Ingestion: | May cause nausea |
| Inhalation: | May cause irritation when used with inadequate ventilation |
| Medical Conditions Aggravated By Exposure: | |
| Allergies to fragrances | |
| Target Organs: | None known |
| This product does not contain any carcinogens or potential carcinogens as listed by OSHA, IARC or NTP. | |
| This material is not considered hazardous by the OSHA Hazard Communication Standard (29 CFR 1910.1200). | |
| Potential Environmental Effects: (See section 12 for more information.) | |
| None known | |
Section 3. Composition/Information on Ingredients
|
| Component | CAS# | % by Weight | WHMIS Controlled |
| Water | 7732-18-5 | 50-90 | N |
| Sodium Citrate | 6132-04-3 | <10% | Y |
| Nonionic Surfactants | Mixture | <10% | N |
| Proprietary Fragrance Mixture | Mixture | <1% | N |
| Acrylate Copolymer | Proprietary | <10% | Y |
Section 4. First Aid Measures |
| Eye Contact: | Flush eyes with copious amounts of clean water, holding lids open. If irritation persists, consult a physician. |
| Skin Contact: | Wash with soap and water. |
| Inhalation: | Remove to fresh air. |
| Ingestion: | Give water to drink if conscious. Do not induce vomiting. |
| Note to Physicians: |
Section 5. Fire Fighting Measures |
| Suitable Extinguishing Media: | Water, foam, carbon dioxide, dry chemical |
| Unsuitable Extinguishing Media: | None known |
| Products of Combustion: | None known |
| Protection of Firefighters: | As for surrounding fire |
Section 6. Accidental Release Measures
|
| Personal Precautions: | Keep away from skin and eyes. Use safety goggles and gloves. |
| Environmental Precautions: | Keep out of surface waters |
| Methods for Containment: | Dike area with sand, clay or other suitable material. |
| Methods for Clean-Up: | Absorb on sand, clay or other suitable material or mop up with water. |
| Other Information: |
Section 7. Handling and Storage
|
| HANDLING |
| Reasonable care. Keep away from skin and eyes. |
| STORAGE |
| Original container at ambient temperatures (below 55°C/130°F) |
Section 8. Exposure Controls/Personal Protection |
| EXPOSURE GUIDELINES | ||
| COMPONENT: | TWA: | LD-50 |
| Water | Not applicable | Not applicable |
| Sodium Citrate | None established | None established |
| Nonionic Surfactants | None established | None established |
| Proprietary Fragrance Mixture | None established | Not established |
| Acrylate Copolymer | NA | NA |
| Engineering Controls: Not normally necessary | ||
| Eye/Face Protection: Protective goggles recommended if handling large quantities | ||
| Skin Protection: Rubber or other protective gloves recommended if handling large quantities | ||
| Respiratory Protection: Not normally necessary | ||
| General Hygiene Considerations: Keep out of food and beverages | ||
Section 9. Physical and Chemical Properties
|
| Color: Pale yellow | Odor: Mild characteristic aroma |
| Physical State: Liquid | Odor Treshhold: |
| pH: 7.5-9.5 | Freezing Point: Not determined |
| Evaporation Rate: As water | Boiling Point: 100°C/212°F |
| Flash Point: >96 C / >205 F PMCC | Flammability(solid,gas): Not applicable |
| Upper Flammability Limit: Not determined | Lower Flammabilty Limit: Not determined |
| Vapor Pressure: As water | Specific Gravity: 1.02-1.05 |
| Vapor Density: Not determined | Auto-ignition Temperature: Not determined |
| Volatile Organic Compound (VOC),%weight: | Solubility (water): Soluble |
| Less than 2 | Percent Volatile: Not determined |
Section 10. Stability and Reactivity
|
| Stability: Stable |
| Conditions to Avoid: None known |
| Incompatable Materials: Strong acids |
| Hazardous Decomposition Products: None known |
| Possibility of Hazardous Reactions: Will not occur |
Section 11. Toxicology Information
|
| ACCUTE EFFECTS | |
| Oral LD50: | Not determined for mixture. Weighted average more than 10 grams per kilogram. |
| Dermal LD50: | Not classified as toxic by skin contact. Weighted average more than 10 grams per kilogram. |
| Inhalation: | Not classified as toxic by inhalation. Weighted average more than 8 milligrams per Liter. |
| Eye Irritation: | Direct contact can irritate eyes |
| Skin Irritation: | Prolonged or repeated contact can irritate or dry skin |
| Sensitization: | None known |
| CHRONIC EFFECTS | |
| Carcinogenicity: | None known |
| Mutagenicity: | None known |
| Reproductive Effects: | None known |
| Developmental Effects: | None known |
Section 12. Ecological Information
|
| Ecotoxicity: | None known |
| Persistence/Degradability: | Biodegradable |
| Bioaccumulation/Accumulation: | None known |
| Mobility in Enviroment: | Not determined |
Section 13. Disposal Considerations
|
| Disposal: | Dispose according to government regulations |
Section 14. Transportation Information |
| US DOT (ground) |
| Proper Shipping Description: Not a Hazardous Material |
| CANADA TDG (ground) |
| Proper Shipping Description: Not a Dangerous Good |
| ICAO (air) |
| Proper Shipping Description: Not a Dangerous Good |
| IMDG (water) |
| Proper Shipping Description: Not a Dangerous Good |
Section 15. Regulatory Information
|
| Global Inventories | |
| TSCA: United States | Included |
| DSL: Canada | Included |
| ECL: Korea | Not-Known |
| PICCS: Philippines | Not-Known |
| ENCS: Japan | Not-Known |
| AICS: Australia | Included |
| IECS: China | Not-Known |
| EINECS: European Union | Included |
| SARA 313 Information : | No SARA 313 substances present at reportable levels |
| California Safe Drinking Water and Toxic Enforcement Act pf 1986 :(Proposition 65) | |
| No Proposition 65 substances present | |
| WHMIS: Canadian Workplace Hazardous Material Information System | |
| non-hazardous | |
Section 16. Other Information
|
| Legends: | |
| NFPA, HMIS: | |
| 0=Minimal Hazard, 1=Slight Hazard, 2=Moderate Hazard, 3=Severe Hazard, 4=Extreme Hazard | |
| Prepared By: | Technical Dept. |
| While we believe that the data contained herein are factual and the opinions expressed are those of qualified experts regarding the results of tests conducted, the data are not to be taken as warranty or representation for which we assume legal responsibility. The information is offered solely for your consideration, investigation and verification. Any use of these data and information must be determined by the user to be in accordance with federal, state and local laws. | |