MATERIAL SAFETY DATA SHEET
| Sheet No. 59 | Revision Date: 20 June 2011 |
|
|
|
MATERIAL SAFETY DATA SHEET |
||
| HMIS: Health- 1 Flammability- 1 Reactivity- 0 Pers. Protection- N |
NFPA: Health- 1 Flammability- 1 Reactivity- 0 Special Hazard- N |
WHMIS:
Not regulated | ||
Section 1: Product and Company Identification |
Product: NILOGEL (Non-Chlorinated)
|
Synonyms: Nilogel, Non-Chlorinated |
| NILODOR, INC. | |
10966 INDUSTRIAL PARKWAY NW
BOLIVAR, OHIO 44612, USA |
|
Non-Emergency: |
24 hr Emergency Spill Information: |
US 800-443-4321
|
Chem-Tel, Inc. |
International 010-330-874-1017
|
US, Canada: 800-255-3924. International: 1-813-248-0584 |
Section 2. Hazards Identification
|
| EMERGENCY OVERVIEW | |
| Appearance/Odor: | Fine white powder |
| NOT Classified as hazardous by the criteria of NOHSC. | |
| WARNING | |
| Flammability : | Not classified as flammable |
| Health Hazards Listed : May be a mild irritant | |
| Ecological Hazards Listed : None known | |
| Potential Health Effects: See section 11 for more information. | |
| Likely Routes of Exposure: Skin, eyes | |
| Eye: | Direct exposure can irritate |
| Skin: | Prolonged or repeated exposure can irritate |
| Ingestion: | Not expected to be a problem |
| Inhalation: | Not likely to be a problem |
| Medical Conditions Aggravated By Exposure: | |
| Allergies to fragrances | |
| Target Organs: | None known |
| This product does not contain any carcinogens or potential carcinogens as listed by OSHA, IARC or NTP. | |
| This material is not considered hazardous by the OSHA Hazard Communication Standard (29 CFR 1910.1200). | |
| Potential Environmental Effects: (See section 12 for more information.) | |
| None known | |
Section 3. Composition/Information on Ingredients
|
| Component | CAS# | % by Weight | WHMIS Controlled |
| Sodium Polyacrylate | 9003-04-7 | 40 - 60 | N |
| Starch | 9005-25-8 | 40 - 60 | N |
| Odor Counteractant | NA | 1-3 | N |
Section 4. First Aid Measures |
| Eye Contact: | Flush with copious amounts of clean water, holding lids apart. If irritation persists, consult a physician. |
| Skin Contact: | Wash with soap and water. |
| Inhalation: | Remove to fresh air. |
| Ingestion: | Give water or milk to drink if conscious. |
| Note to Physicians: | Forms a gel with liquids, including gastric fluid. Large quantities of water will spread gel into a slurry than can be rinsed out of eyes. Gel is soft. |
Section 5. Fire Fighting Measures |
| Suitable Extinguishing Media: | Water, foam, carbon dioxide, dry chemical |
| Unsuitable Extinguishing Media: | None known |
| Products of Combustion: | Oxides of carbon and nitrogen |
| Protection of Firefighters: | As for surrounding fire |
Section 6. Accidental Release Measures
|
| Personal Precautions: | Keep away from skin and eyes |
| Environmental Precautions: | Keep out of surface waters. |
| Methods for Containment: | If slurry, dike with sand, clay or other suitable material. Gel or unwetted powder will not flow. |
| Methods for Clean-Up: | Scoop or shovel up for disposal. |
| Other Information: |
Section 7. Handling and Storage
|
| HANDLING |
| Keep dry and away from skin and eyes |
| STORAGE |
| Keep in closed, original container at ambient temperatures (5-50°C) |
Section 8. Exposure Controls/Personal Protection |
| EXPOSURE GUIDELINES | ||
| COMPONENT: | TWA: | LD-50 |
| Sodium Polyacrylate | None established | >5000 mg/kg |
| Starch | None established | >5000 mg/kg |
| Odor Counteractant | NA | NA |
| Engineering Controls: Not normally necessary | ||
| Eye/Face Protection: Protective goggles recommended if handling large quantities | ||
| Skin Protection: Rubber or other protective gloves recommended if handling large quantities | ||
| Respiratory Protection: Dust mask or respirator recommended if handling large quantities | ||
| General Hygiene Considerations: Keep out of food and beverages | ||
Section 9. Physical and Chemical Properties
|
| Color: White | Odor: Spicy |
| Physical State: Fine powder | Odor Treshhold: |
| pH: Not applicable | Freezing Point: Not applicable |
| Evaporation Rate: Not applicable | Boiling Point: Not applicable |
| Flash Point: Not applicable | Flammability(solid,gas): Not considered flammable |
| Upper Flammability Limit: Not determined | Lower Flammabilty Limit: Not determined |
| Vapor Pressure: Less than 0.01 Torr at 20°C | Specific Gravity: Not applicable. Bulk density, tapped, not less than 0.45 g/mL |
| Vapor Density: Not determined | Auto-ignition Temperature: Not determined |
| Volatile Organic Compound (VOC),%weight: | Solubility (water): Forms gel with up to 100 times its mass; forms slurry with larger quantities of water |
| Less than 2%, all fragrance | Percent Volatile: Less than 2%, all fragrance |
Section 10. Stability and Reactivity
|
| Stability: Stable |
| Conditions to Avoid: None known |
| Incompatable Materials: None known |
| Hazardous Decomposition Products: None known |
| Possibility of Hazardous Reactions: Extremely improbable |
Section 11. Toxicology Information
|
| ACCUTE EFFECTS | |
| Oral LD50: | Not determined for mixture. Weighted average more than 1200 mg/kg. |
| Dermal LD50: | Not determined. Weighted average more than 2 grams per kilogram. |
| Inhalation: | Not determined. No components classified as toxic by inhalation at concentrations present. Weighted average more than 3 milligrams per Liter. |
| Eye Irritation: | Direct contact can irritate eyes |
| Skin Irritation: | Prolonged or repeated contact can irritate or dry skin |
| Sensitization: | None known |
| CHRONIC EFFECTS | |
| Carcinogenicity: | None known |
| Mutagenicity: | None known |
| Reproductive Effects: | None known |
| Developmental Effects: | None known |
Section 12. Ecological Information
|
| Ecotoxicity: | None known |
| Persistence/Degradability: | Biodegradable |
| Bioaccumulation/Accumulation: | Not determined |
| Mobility in Enviroment: | Not determined |
Section 13. Disposal Considerations
|
| Disposal: | Dispose according to Federal, State and Local regulations |
Section 14. Transportation Information |
| US DOT (ground) |
| Proper Shipping Description: Not a Hazardous Material |
| CANADA TDG (ground) |
| Proper Shipping Description: Not a Dangerous Good |
| ICAO (air) |
| Proper Shipping Description: Not a Dangerous Good |
| IMDG (water) |
| Proper Shipping Description: Not a Dangerous Good |
Section 15. Regulatory Information
|
| Global Inventories | |
| TSCA: United States | Included |
| DSL: Canada | Included |
| ECL: Korea | Not-Known |
| PICCS: Philippines | Not-Known |
| ENCS: Japan | Not-Known |
| AICS: Australia | Included |
| IECS: China | Not-Known |
| EINECS: European Union | Included |
| SARA 313 Information : | No SARA 313 substances present at reportable levels |
| California Safe Drinking Water and Toxic Enforcement Act pf 1986 :(Proposition 65) | |
| No Proposition 65 substances present | |
| WHMIS: Canadian Workplace Hazardous Material Information System | |
| Not regulated | |
Section 16. Other Information
|
| Refers to product made on or after 9 March 2006 | |
| Legends: | |
| NFPA, HMIS: | |
| 0=Minimal Hazard, 1=Slight Hazard, 2=Moderate Hazard, 3=Severe Hazard, 4=Extreme Hazard | |
| Prepared By: | Technical Dept. |
| While we believe that the data contained herein are factual and the opinions expressed are those of qualified experts regarding the results of tests conducted, the data are not to be taken as warranty or representation for which we assume legal responsibility. The information is offered solely for your consideration, investigation and verification. Any use of these data and information must be determined by the user to be in accordance with federal, state and local laws. | |